| Title: | Occupational hygiene in a Finnish drum composting plant |
| Author(s): | Tolvanen O; Nykanen J; Nivukoski U; Himanen M; Veijanen A; Hanninen K; |
| Address: | "University of Jyvaskyla, Department of Biological and Environmental Science, P.O. Box 35, 40014 University of Jyvaskyla, Finland. outolvan@bytl.jyu.fi" |
| DOI: | 10.1016/j.wasman.2005.02.011 |
| ISSN/ISBN: | 0956-053X (Print) 0956-053X (Linking) |
| Abstract: | "Bioaerosols (microbes, dust and endotoxins) and volatile organic compounds (VOCs) were determined in the working air of a drum composting plant treating source-separated catering waste. Different composting activities at the Oulu drum composting plant take place in their own units separated by modular design and constructions. Important implication of this is that the control room is a relatively clean working environment and the risk of exposure to harmful factors is low. However, the number of viable airborne microbes was high both in the biowaste receiving hall and in the drum composting hall. The concentration (geometric average) of total microbes was 21.8 million pcs/m3 in the biowaste receiving hall, 13.9 million pcs/m3 in the drum composting hall, and just 1.4 million pcs/m3 in the control room. Endotoxin concentrations were high in the biowaste receiving hall and in the drum composting hall. The average (arithmetic) endotoxin concentration was over the threshold value of 200 EU/m3 in both measurement locations. In all working areas, the average (arithmetic) dust concentrations were in a low range of 0.6-0.7 mg/m3, being below the Finnish threshold value of 5 mg/m3. In the receiving hall and drum composting hall, the concentrations of airborne microbes and endotoxins may rise to levels hazardous to health during prolonged exposure. It is advisable to use a respirator mask (class P3) in these areas. Detected volatile organic compounds were typical compounds of composting plants: carboxylic acids and their esters, alcohols, ketones, aldehydes, and terpenes. Concentrations of VOCs were much lower than the Finnish threshold limit values (Finnish TLVs), many of the quantified compounds exceeded their threshold odour concentrations (TOCs). Primary health effects due VOCs were not presumable at these concentrations but unpleasant odours may cause secondary symptoms such as nausea and hypersensitivity reactions. This situation is typical of composting plants where the workers are exposed to dozens of VOCs simultaneously. The odour units (OU/m3) were measured using olfactometer. The numbers were 23,000 OU/m3 at the output end of the composting drum and 6300 OU/m3 in the exhaust pipe. Inside the composting hall, the number of odour units was 500 and 560 OU/m3" |
| Keywords: | "Aerosols Air Pollution, Indoor/*analysis Dust Endotoxins/*analysis Finland Humans *Occupational Exposure *Occupational Health Odorants Organic Chemicals/analysis *Refuse Disposal Volatilization;" |
| Notes: | "MedlineTolvanen, Outi Nykanen, Jenni Nivukoski, Ulla Himanen, Marina Veijanen, Anja Hanninen, Kari eng Research Support, Non-U.S. Gov't 2005/05/05 Waste Manag. 2005; 25(4):427-33. doi: 10.1016/j.wasman.2005.02.011" |
