| Title: | Inhalation exposure to volatile organic compounds in the printing industry |
| Author(s): | Alabdulhadi A; Ramadan A; Devey P; Boggess M; Guest M; |
| Address: | "School of Health Sciences, Faculty of Health and Medicine, University of Newcastle , Callaghan , NSW , Australia. Public Authority of Applied Education and Training , Shuwaikh , Kuwaitu. Kuwait Institute of Scientific Research , Safat , Kuwait. School of Mathematical and Statistical Sciences, Arizona State University , Tempe , AZ , USA" |
| DOI: | 10.1080/10962247.2019.1629355 |
| ISSN/ISBN: | 2162-2906 (Electronic) 1096-2247 (Linking) |
| Abstract: | "This study reports on the occupational inhalation exposure to VOCs of workers in the Kuwaiti printing industry. Using the evacuated canister methodology, we targeted 72 VOCs in three printeries and compared the concentrations to previous reports and relevant occupational exposure levels (OELs). We found that recent efforts in the printing industry to reduce VOC usage had been successful, as concentrations of key hazardous VOCs were substantially lower than anticipated. On the other hand, nearly all target VOCs were found. Non-production areas were sampled along with the offset printing areas, another strength of this study, and revealed exposures to hazardous VOCs among administers and digital printer and CTP operators. Exposure to ototoxic VOCs amounted to 1-3% of the OEL, consisting mostly of ethylbenzene, which was likely in use in two of the study printeries. Exposure to carcinogenic or probably carcinogenic VOCs was 15-20% of the OEL at four locations across the three printeries, consisting mostly of vinyl chloride and benzyl chloride. Vinyl chloride VOC was partially sourced from outdoors, but was also likely used inside the study printeries. Interestingly, concentrations of vinyl chloride were similar in most sampling locations to that of CFC-114, a CFC banned by the Montreal Protocol and not commonly used as a refrigerant. This unexpected finding suggests further study is warranted to identify the use of these VOCs in printeries. Exposure to hazardous VOCs up to nearly 50% of the OEL, consisting largely of bromoform and vinyl chloride. Bromoform was found in all the study printeries, sourced partially from outdoor air. The higher concentrations found inside the study printeries likely resulted from the use of the desalinated water for washing. This finding raises of emissions from sources other than blanket washes, and inks, etc. adding to the total VOC load in printery indoor air. Implications: Results from this study indicate that efforts to reduce worker exposure to VOCs particularly dangerous to human health in recent years have been successful, but there is still much to be done to protect workers. Exposures to ototoxic and carcinogenic VOCs were identified, among both production and non-production workers. Unexpected findings included the apparent use in printing activities of the carcinogen vinyl chloride and CFC-114, banned under the Montreal Protocol. Observed lapses in safety procedures included failure to utilize ventilation systems and closing doors between work areas, indicating management and worker education should remain a priority" |
| Keywords: | "Air Pollutants, Occupational/*analysis Benzene Derivatives/analysis Benzyl Compounds/analysis Environmental Monitoring/methods Humans Industry Inhalation Exposure/*analysis Occupational Exposure/*analysis *Printing Trihalomethanes/analysis Vinyl Chloride/;" |
| Notes: | "MedlineAlabdulhadi, Abdullah Ramadan, Ashraf Devey, Peter Boggess, May Guest, Maya eng Research Support, Non-U.S. Gov't 2019/06/12 J Air Waste Manag Assoc. 2019 Oct; 69(10):1142-1169. doi: 10.1080/10962247.2019.1629355" |
